Product ID:TT-E 2124B BLACK 27038 ORGANIC COATING F-03P14
MSDS Date:03/15/1994
FSC:8010
NIIN:01-078-8665
MSDS Number: BVVCM

SEAGRAVE COATINGS CORP OF VA

4030 SEAGUARD AVE
PORTSMOUTH, VA 23701-2636
US

Emergency Phone: 804-488-4411

Info Phone: 804-488-4411

Cage: 60163

SHERWIN-WILLIAMS, SEAGUARD

PORTSMOUTH, VA 23704 US

Telephone: 757-397-2223

Cage: 60163

CARBON BLACK (VAPOR PRESSURE 0 MM HG @ 20C)

CAS: 1333-86-4

RTECS: FF5800000

Fraction By Weight: <5%

ACGIH TLV: 3.5 MG/M3

BLACK IRON OXIDE (VAPOR PRESSURE 0 MM HG @ 20C)

CAS: 1317-61-9

Fraction By Weight: <5%

ACGIH TLV: 5 MG/M3

BARYTES (BARIUM SULFATE) (VAPOR PRESSURE 0 MM HG @ 20C)

CAS: 7727-43-7

RTECS: CR0600000

Fraction By Weight: <10%

ACGIH TLV: 10 MG/M3

XYLENE (SARA III) (VAPOR PRESSURE 7.0 MM HG @ 20C) (SKIN)

CAS: 1330-20-7

RTECS: ZE2100000

Fraction By Weight: <15%

ACGIH TLV: 100 PPM;STEL 150 PPM

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

METHYL ISOBUTYL KETONE (SARA III) (VAPOR PRESSURE 16.0 MM

CAS: 108-10-1

RTECS: SA9275000

Fraction By Weight: <45%

ACGIH TLV: 50 PPMO;STEL 75 PPMO

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

584 GR/LTR (4.87 LB/GL)

RTECS: 9999999VO

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Health Hazards Acute and Chronic:BREATHING OF HIGH VAPOR CONCENTRATIONS
MAY PRODUCE NARCOSIS. MINOR SKIN IRRITATION & DEFINITE EYE
IRRITATION. NOSE & THROAT IRRITATION. EYE IRRITATION. SKIN
IRRITATION. REPEATED & PROLONGED OVEREXPOSU RE COULD CAUSE
PERMANENT BRAIN & NERVOUS SYSTEM DAMAGE. CONCENTRATING & INHALING
CONTENTS MAY BE HARMFUL OR FATAL.
Medical Cond Aggravated by Exposure:DEGENERATION OF THE KIDNEY AND TO A
LESSER EXTENT THE LIVER.

First Aid:INHALTION: REMOVE TO FRESH AIR, RESTORE BREATHING. CONSULT
PHYSICIAN. SKIN: FLUSH WITH WATER/WASH THOROUGHLY WITH SOAP &
WATER. EYE CONTACT: FLUSH IMMEDIATELY WITH LARGE AMOUNT OF WATER AT
LEAST 15 MI NUTES. CONSULT PHYSICIAN IMMEDIATELY. ASPIRATED MIBK
MAY CAUSE SEVERE LUNG DAMAGE, STOMACH SHOULD BE EVACUATED QUICKLY,
AVOIDING ASPIRATION. INGESTION: IF SWALLOWED, GET MEDICAL ATTENTION
IMMEDIATELY.

Flash Point Method:SCC
Flash Point:60.0F,15.6C
Lower Limits:1.0
Upper Limits:7.0
Extinguishing Media:WATER FOG, CARBON DIOXIDE, DRY CHEMICAL, FOAM,
ALCOHOL
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED GAS MASK FOR FIRE
FIGHTING PERSONNEL. WATER MAY BE USED TO COOL CONTAINERS. IF WATER
IS USED FOG NOZZLES ARE PREFERRED.
Unusual Fire/Explosion Hazard:KEEP CONTAINER CLSD.VAPOR MAY MIGRATE TO
IGNITN SOURCE & CAUSE FLASH FIRE.KEEP FROM HEAT,SPARK,ELEC
EQUIP,APPLIANCE,OTHER IGNITION SOURCE.FLAMMABLE LIQ & VAPOR.

Spill Release Procedures:IN CASE OF SPILLAGE ABSORB WITH INERT MATERIAL
AND DISPOSE OF IN ACCORDANCE WITH APPLICABLE REGULATIONS OF EPA AND
OTHER LOCAL, STATE, AND FEDERAL AUTHORITIES.

Handling and Storage Precautions:STORE AWAY FROM HEAT,SPARK,FLAME.AVOID
PROLONGED SKIN CONTACT.DON'T BREATHE SPRAY MIST.EMPTY CNTNR MAY
RETAIN HAZARDOUS PROPERTIES-CAN BE DANGEROUS.
Other Precautions:STORE IN A COOL DRY AREA WITH VENTILATION SUITABLE
FOR STORING MATERIALS SHOWN IN INGREDIENT SECTION. GROUND
CONTAINERS WHILE POURING. AVOID SPONTANEOUS COMBUSTION OF
CONTAMINATED RAGS OR OTHER ORGANI C MATERIALS.

Respiratory Protection:NIOSH/OSHA RESPIRATOR TYPE SUITABLE FOR MAT'L.
APPROVED CHEMICAL/MECHANICAL RILTERS RECOMENDED WHEN VENTILATION
RESTRICTED. DO NOT BREATHE. WEAR APPROPRIATE RESPIRATOR DURING &
AFTER APPLICATION UNLES S BELOW PEL. FOLLOW RESP MFR DIRECTION.
Ventilation:VENT TO KEEP AIR CONTAMINATION BELOW CURRENT APPLICABLE
OSHA PEL OR ACGIH TLV. USE WITH ADEQUATE VENTILATION.
Protective Gloves:CHEM RESISTANT PLASTIC OR RUBBER
Eye Protection:CHEM GOGGLES W/SIDE SHIELDS OR FACE SHLD
Other Protective Equipment:AS REQ'D TO AVOID WETTING CLOTHES. USE
PROTECTIVE CREAMS WHERE SKIN CONTACT LIKELY. EYE BATH AND SAFETY
SHOWER.
Work Hygienic Practices:AVOID CONTACT WITH EYES, SKIN & CLOTHING. WASH
THOROUGHLY AFTER HANDLING. REMOVE & WASH CONTAM CLOTHING BEFORE
REUSE.
Supplemental Safety and Health

Boiling Pt:B.P. Text:147 TO 284F
Vapor Density:> AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:INSOLUBLE
Appearance and Odor:LIQUID, SOLVENT
Percent Volatiles by Volume:71.4

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:EXCESSIVE HEAT, SPARKS OR OPEN FLAME.
Hazardous Decomposition Products:COMBUSTION WILL PRODUCE CARBON DIOXIDE
AND PROBABLY CARBON MONOXIDE.

Waste Disposal Methods:PLACE IN CLOSED CONTAINERS. DISPOSE OF PRODUCT
IN ACCORDANCE WITH LOCAL, COUNTY, STATE, AND FEDERAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.